How to saw wood to make hand held stilts from http://dangerouslyfun.com/stilts.html
Want to raise your hight from one to three extra feet? These are adjustible and a ton of fun whether you are looking to get your blood rushing with 3 feet or rise above your friends at one foot. You need to wrap your arms around each of the stilts and lift them up as you walk along. Once you get the hang of it, you will be a pro without anything in your way, not even going up and down hills!
| Danger Level | Materials | Tools |
| NEGLIGIBLE | A. Wooden 2 × 4, 15.5″ long | F. Table saw or similar |
| moderate | B. (4) 3/8″ wing nuts | G. Drill |
| high | C. (4) 3/8″ ID flat washers | |
| do not do this | D. (4) 3/8″ x 4″ carriage bolts | |
| E. (2) Wooden poles, 8′ x 1.5″ x 1.5″ |
how-to
1. Cut the 2×4 at a 45° angle, forming two congruent trapezoids. The parallel sides should measure 6 inches and 9.5 inches. These two pieces will be the footholds.
2. On the short side of the footholds, bore two holes 1.5″ deep with a 3/4″ wing bit. These holes should be spaced 4 inches apart (center to center). They will allow the carriage bolts to extend through far enough to get the wing nuts on.
3. With a 3/8″ bit, finish drilling the holes all of the way through. The footholds are now finished.
4. You need to drill eight 3/8″ holes in both of the 8′ poles. Start 6″ from the bottom and drill a hole every 4″ until you are 34″ from the bottom.
5. Place the footholds at whatever height you want (start low), insert the bolts, and tighten on the wing nuts with the washers underneath.
6. To get onto the stilts, either back yourself up against a wall and step up as the stilts lean against the wall or have a trusted, strong friend hold them for you. Beginners often want to hold the poles in front of them, but is is impossible to balance that way. You have to place the poles placed behind your arm pits and wrap your arms around the front of them.
7. If you notice that the bottom of the stilts start to splinter as you use them, wrap some electrical or duct tape around the bottoms to slow the process.
Another How to Build Stilts. Also has how to walk on your stilts.
Leave a Reply
You must be logged in to post a comment.
